Results 1 to 10 of 10
  1. #1
    wolfism Guest

    Default John Tams Pottery, Longton - May ‘11

    Cities never sleep so deeply that they fall completely still. Even at the deadest point of night, when good people are dreaming of better times, and bad people have passed out worse for wear - the city shifts, lights trace along the main roads, and buildings shrug off night rain. 5am. As I stood at a window five storeys up in a Travelodge, looking out over a darkened ring road, blue lights flashed in the distance. Take it as read that something is always happening somewhere in the Six Towns – and sometimes that means someone is making ready to go somewhere they shouldn't be. Perhaps that's why Arnold Bennett cleared out…





    By the time I reached Longton, driving along a ring road which slices past John Tams’ Crown Pottery, light was rising in the east. The Strand - the busy street which Tams' pottery sits on - was still quiet, but no doubt bus drivers, milkmen and bakers were already stirring in their scratchers. Crown Works is a deceptive factory, a series of two and three storey buildings which form a wall around a single-storey core. Most are built from an umber-coloured brick which looks dour in bad weather, but lends sobriety to their appearance. Delivery trucks were revving up in far-flung depots and the dawnbirds were clearing their throats when I found myself inside, standing in a darkened delivery bay with a pair of grimy maroon-painted swing doors that opened out into a bright factory floor.





    The pottery is still full of mugs and moulds, dies and patterns, bins full of slip and containers of glaze. The whole is covered in a film of pale clay dust which has settled over the course of five years since Crown Works closed. Arrayed on one side is a series of electric kilns, their refractory-lined doors swung wide, with little kiln cars still intact in front of them on miniature rails. Along another edge is a bigger tunnel kiln: relative to the tunnel kilns you find in brick or tile works, it's small scale, but must have once held tens of thousands of mugs, travelling past gas burners through heating and cooling zones until they were fired. Upstairs are ransacked offices with paper strewn everywhere - but the interesting part of Tams is the production floor, lit by a set of glazed lantern rooflights.





    The company operated from the Crown Works on The Strand in Longton (this one) and also had the Blythe, Sutherland, and Atlas works in Longton, and a warehouse at the former Monarch flatware site in Fenton. Crown Works lies on an island site at the corner of Commerce St and the Strand – it was founded in 1841 by John Goodwin, and he occupied the site until 1851. Meanwhile, John Tams was born in Longton in 1837 and by the time he was 12 years old, was apprenticed to a working potter. Around 1865 he entered into partnership with William Lowe, manufacturing in St. Gregory's Pottery, High Street, Longton as Tams & Lowe. The partnership was dissolved about 1873 and in 1875 John Tams went into business on his own account, and bought the Crown Pottery. At first he specialised in the manufacture of imperial measured ware, such as mugs, jugs and so forth for hotels and public houses. The increasing use of glassware forced him to develop new lines, including ornamental and general earthenware – which is why Tams came to specialise in mugs.





    In 1903 the firm became became John Tams & Son, and in 1912 was incorporated as John Tams Ltd. The Factory originally had 3 bottle kilns, none of which survive today, as it was rebuilt sometime around the 1940’s or ‘50’s: the rooflit kiln floor you see in the photos replaced the old kilns. By the end of the 20th century, the Tams group was one of the last great family-run pottery firms in Stoke-on-Trent, continuing to grow through the 1980’s from two factories to five. By the time it went into receivership in 2000, Tams employed 730 people – but was bought out by the management to create Tams Group Ltd., who purchaced the rights to Tams, Royal Grafton, Grafton Living and Duchess Bone China. In 2002 the newly revivified Tams was valued at £33m: it was growing again, becoming the biggest ceramic employer in Longton, and one of the biggest mugs manufacturer in Europe. However, its success was short-lived and in 2006 the group went into receivership for a second time, and the Crown Works closed, ending over 160 years of ceramic manufacturing on the site.





    As the morning wore on, the first service buses and bread lorries headed along The Strand - a particularly keen window cleaner was already hard at work by 7am. The volume of traffic on the ring road gradually increased until it impinged constantly on my concentration, signalling that it was time to go. Either that, or be forced to sit quietly all day inside the disused pottery, with parents dragging fractious kids past its windows just a few feet away, and a constant flow of traffic heading past the factory gates.




  2. The Following User Says Thank You to wolfism For This Useful Post:

    foz101 (28-05-2011)

  3. #2
    Join Date
    Feb 2011
    Location
    selby, north yorkshire
    Posts
    89
    Thanks
    28
    Thanked 13 Times in 13 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    niceshots detailed story too!

  4. #3
    Join Date
    Jun 2010
    Location
    Yorkshire! Salt of the earth!
    Posts
    1,905
    Thanks
    176
    Thanked 577 Times in 468 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    mmmmm nice


    "How come the compression is so bad on all those shots man? It looks like they've been edited with a Commodore 64." JST

  5. #4
    Join Date
    Oct 2010
    Location
    Bulgaria
    Posts
    972
    Thanks
    198
    Thanked 323 Times in 291 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    What a grand write up and pics!

  6. #5
    Join Date
    Aug 2009
    Location
    The land where men are men and sheep are dumb
    Posts
    685
    Thanks
    44
    Thanked 157 Times in 120 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    Another wolfism classic report. Nice one mate
    ON A JOURNEY OF DECAY

  7. #6
    Join Date
    Sep 2010
    Location
    brighouse
    Posts
    276
    Thanks
    9
    Thanked 37 Times in 33 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    V nice report and pic's too.....cheers for posting.....
    ...

  8. #7
    Join Date
    Mar 2010
    Location
    Warrington
    Posts
    628
    Thanks
    42
    Thanked 236 Times in 179 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    top stuff mate

  9. #8
    Join Date
    Aug 2010
    Location
    Manchester
    Posts
    212
    Thanks
    1
    Thanked 43 Times in 35 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    Great stuff, was here recently too, loved it, must get back to Stoke.
    Frequently In The Confines Of Abandonments

  10. #9
    Join Date
    Mar 2011
    Location
    Leeds
    Posts
    774
    Thanks
    100
    Thanked 414 Times in 279 Posts

    Default Re: John Tams Pottery, Longton - May ‘11

    Nice shots, you captured the goodness here, I was surprised by how ultimately fucked the offices upstairs were.

  11. #10
    wolfism Guest

    Default Re: John Tams Pottery, Longton - May ‘11

    Cheers all. Yeah, agreed, the offices are pretty far gone, I mainly concentrated on the kilns and so forth downstairs…

Similar Threads

  1. Crown Works (John Tams) - Stoke On Trent - May 2011
    By hiddenshadow in forum Industrial sites
    Replies: 4
    Last Post: 18-05-2011, 09:32 PM
  2. Replies: 7
    Last Post: 02-05-2011, 12:17 AM
  3. Replies: 5
    Last Post: 17-11-2010, 12:14 AM
  4. John Tams, Crown works, Stoke, May 2010
    By Eotech in forum Industrial sites
    Replies: 4
    Last Post: 10-05-2010, 08:11 AM
  5. Archived: Longton ROC Post - (Lancashire Group) - July 08
    By KingElvis in forum Lancashire
    Replies: 0
    Last Post: 31-07-2008, 07:26 PM

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •